View D464-R13-001_4473758.PDF datasheet online --- IC-ON-LINE

Datasheet File OCR Text:

document no. 91 00-127-1541-99 rev a n ovember 17, 2011 ___________________________________________________ __________________ ___________________________________________________ __________________________ dialight corporation 1501 route 34 south farmi ngdale nj 07727 tel: 732.919.3119 fax: 732.751.5778 web: www .dialight.com 1 of 12 installation and maintenance manual for p/n: d464r13001 120/240vac, 50/60 hz, l864 red / infrared medium intensity beacon www.datasheet.co.kr datasheet pdf - http://www..net/
document no. 91 00-127-1541-99 rev a n ovember 17, 2011 ___________________________________________________ __________________ ___________________________________________________ __________________________ dialight corporation 1501 route 34 south farmi ngdale nj 07727 tel: 732.919.3119 fax: 732.751.5778 web: www .dialight.com 2 of 12 contents page list of figures and tables ......................... ................................................... .....2 reference drawings ................................. ................................................... .......2 section 1: overview................................ ................................................... .........3 section 2: wiring and mounting ..................... ................................................... 4 section 3: operation and test ...................... ................................................... ..5 section 4: beacon theory of operation.............. ..............................................5 section 5: maintenance and troubleshooting......... .........................................6 section 6: specifications .......................... ................................................... ....10 section 7: regulatory compliance and certifications ...................................10 section 8: how to obtain warranty service .......... .........................................10 beacon wiring diagram .............................. ................................................... ..11 list of figures and tables figure 1: l-864 flashing red beacon assembly figure 2: base - bottom view figure 3: system block diagram figure 4: beacon C external view figure 5: beacon in open position figure 6: light engine install/removal table 1: troubleshooting reference drawings beacon wiring diagram www.datasheet.co.kr datasheet pdf - http://www..net/
document no. 91 00-127-1541-99 rev a n ovember 17, 2011 ___________________________________________________ __________________ ___________________________________________________ __________________________ dialight corporation 1501 route 34 south farmi ngdale nj 07727 tel: 732.919.3119 fax: 732.751.5778 web: www .dialight.com 3 of 12 section 1: overview the dialight flashing red beacon is designed for th e lighting of radio towers, wind generators and other obstructions to aerial na vigation, as specified by the faa, fcc, icao and transport canada. the l-864 series d464 infrared (ir) obstruction lig ht incorporates both red and ir leds in a single unit to ensure visibility aroun d military bases, airfield perimeters, buildings, towers and other obstruction s for aircraft pilots, both during normal flight or when aided by night vision systems . night vision goggles (nvgs) and aviators night vision imaging system (a nvis) often employ class a, b, and c filters. these filters can reduce led s ources that emit light in the visible spectrum. the vigilant l-864 d464 series ov ercomes this obstacle by combining visible red leds and ir leds in a single unit. the l-864 flashing red beacon as shown in figure 1, (hereafter referred to as the beacon) operates from 120 / 240vac 50/60 hz. t he beacon consists of visible-light and infrared-light, high performance leds that provide the light output equivalent to an incandescent fixture while consuming a fraction of the electrical power. this manual provides guidance and recommendations for the installation and testing of the beacon assembly. pl ease read this document in its entirety before installing the beacon. figure 1 l-864 flashing red beacon assembly www.datasheet.co.kr datasheet pdf - http://www..net/
document no. 91 00-127-1541-99 rev a n ovember 17, 2011 ___________________________________________________ __________________ ___________________________________________________ __________________________ dialight corporation 1501 route 34 south farmi ngdale nj 07727 tel: 732.919.3119 fax: 732.751.5778 web: www .dialight.com 4 of 12 section 2: wiring and mounting warning: remove power from all wiring and circuitry before i nstalling or working on the beacon. wiring the beacon the beacon only requires a connection to 120 / 240 vac, 50/60 hz power. the ground wire must be connected for proper operation and protection of the beacon. mounting the beacon dialight recommends the installation of one or more lightning rods near the installed beacon. the lightning rods should extend a minimum of three feet above the height of the beacon. the beacon is mounted to the tower pedestal utilizi ng customer supplied ? hardware. six mounting holes are provided on the be acon base (figure 2). these mounting holes will align with most tower ped estals. the beacon must be installed level according to the bulls-eye level in side the light engine to maintain light output in accordance with faa requirements. figure 2 base - bottom view www.datasheet.co.kr datasheet pdf - http://www..net/
document no. 91 00-127-1541-99 rev a n ovember 17, 2011 ___________________________________________________ __________________ ___________________________________________________ __________________________ dialight corporation 1501 route 34 south farmi ngdale nj 07727 tel: 732.919.3119 fax: 732.751.5778 web: www .dialight.com 5 of 12 section 3: operation and test prior to installation, it is recommended that the u nit be tested to ensure no damage was incurred during shipping. this is accomp lished by applying power to the beacon. visual verification of the functioning of the beacon will indicate proper performance. upon completion of this test, the installation may proceed. section 4: beacon theory of operation 4.0 system overview the block diagram in figure 4 shows the major compo nents of a typical beacon installation. the parts of the system are the led b eacon and controller. the led beacon is made up of one led module, which ligh ts when current passes through it. the led beacon contains its own interna l power supply. the beacon is designed for use with an external controller. th is external controller provides the properly timed flashing signal, fault monitorin g and alarm interfaces. beacon assembly figure 3 - system block diagram external controller power supply led module www.datasheet.co.kr datasheet pdf - http://www..net/
document no. 91 00-127-1541-99 rev a n ovember 17, 2011 ___________________________________________________ __________________ ___________________________________________________ __________________________ dialight corporation 1501 route 34 south farmi ngdale nj 07727 tel: 732.919.3119 fax: 732.751.5778 web: www .dialight.com 6 of 12 4.1 lightning protection the beacon incorporates protection against voltage surges (as induced by nearby lightning strikes for example) by means of a metal oxide varistor (mov) and gas discharge tube (gdt) arrangement. section 5: maintenance and troubleshooting no regularly scheduled maintenance is required for the beacon. general cleaning of the dome assembly should be don e using soapy water. no other cleaning solutions are recommended. abrasive compounds will scratch the dome assembly. table 1 lists possible faults and repair procedures for the l-864 red beacon table 1 troubleshooting symptom possible cause corrective action beacon does not light no ac power led failure power supply failure verify proper ac levels from power source thru supply lines. replace led module replace power supply beacon does not flash refer to controller documentation supplied by the manufacturer. repair and replacement refer to table 1 for troubleshooting procedures. www.datasheet.co.kr datasheet pdf - http://www..net/
document no. 91 00-127-1541-99 rev a n ovember 17, 2011 ___________________________________________________ __________________ ___________________________________________________ __________________________ dialight corporation 1501 route 34 south farmi ngdale nj 07727 tel: 732.919.3119 fax: 732.751.5778 web: www .dialight.com 7 of 12 figure 4 beacon C external view recommended spare parts, user replaceable parts description dialight part number beacon light engine d464-1017 beacon dome d464-2005 o-ring gasket d464-8002 gen iv power supply (inside base) d464-9005 latch beacon dome d464-2005 beacon light engine d464-1017 o-ring gasket d464-8002 (under dome edge) gen iv ir power supply d464-9005 (not pictured C inside base) www.datasheet.co.kr datasheet pdf - http://www..net/
document no. 91 00-127-1541-99 rev a n ovember 17, 2011 ___________________________________________________ __________________ ___________________________________________________ __________________________ dialight corporation 1501 route 34 south farmi ngdale nj 07727 tel: 732.919.3119 fax: 732.751.5778 web: www .dialight.com 8 of 12 the only parts that are serviceable on the beacon a re the light engine and power supply. replacement procedure for the light engine step 1 warning: power to the beacon must be removed prior to servi cing. step 2 unclamp the two latches holding the light en gine down. step 3 rotate the light engine back to its open position. step 4 carefully pull the inline connector between the led module and power supply apart, and than unscrew the grounding strap from the light engine to separate the two assemblies. be careful not to l ose the screw for the ground strap. cable connector ground strap www.datasheet.co.kr datasheet pdf - http://www..net/
document no. 91 00-127-1541-99 rev a n ovember 17, 2011 ___________________________________________________ __________________ ___________________________________________________ __________________________ dialight corporation 1501 route 34 south farmi ngdale nj 07727 tel: 732.919.3119 fax: 732.751.5778 web: www .dialight.com 9 of 12 figure 5 C beacon in open position step 5 rotate the light engine downwards to approximately 10 degrees from the closed position. the key should line up with the ke yway on the hinge and allow for the light engine to be pulled off of its pins. figure 6 C light engine install/removal (dome and c antilever not shown for clarity) step 6 slide the new light engine onto the pins to line it up. rotate it to approximately 10 degrees from closed to again line up the keyway. push the light engine past the key until it clears and t han rotate it back to the open position. step 7 reconnect the inline connector between the light en gine and power supply, followed by the grounding strap. step 8 rotate the light engine down to the closed position and secure the two latches to complete installation. apply power to en sure the beacon lights up correctly. www.datasheet.co.kr datasheet pdf - http://www..net/
document no. 91 00-127-1541-99 rev a n ovember 17, 2011 ___________________________________________________ __________________ ___________________________________________________ __________________________ dialight corporation 1501 route 34 south farmi ngdale nj 07727 tel: 732.919.3119 fax: 732.751.5778 web: www .dialight.com 10 of 12 section 6: specifications power supply specifications (d464-9005) input voltage range 120-240vac at 50/60hz nominal input power 40w power factor >0.9 athd <20% beacon specifications light color red weight 20 pounds height 8.4 inches width 15.0 inches bolt hold down pattern standard pattern provided ( see fig. 2) section 7: regulatory compliance and certifications 7.1 etl certified to: federal aviation administrati on (faa): ac no. (150/5345- 43f). section 8: how to obtain warranty service refer to www.dialight.com www.datasheet.co.kr datasheet pdf - http://www..net/
document no. 91 00-127-1541-99 rev a n ovember 17, 2011 ___________________________________________________ __________________ ___________________________________________________ __________________________ dialight corporation 1501 route 34 south farmi ngdale nj 07727 tel: 732.919.3119 fax: 732.751.5778 web: www .dialight.com 11 of 12 beacon wiring diagram live (black) neutral (white) ground (green) +red -black power supply led module www.datasheet.co.kr datasheet pdf - http://www..net/
document no. 91 00-127-1541-99 rev a n ovember 17, 2011 ___________________________________________________ __________________ ___________________________________________________ __________________________ dialight corporation 1501 route 34 south farmi ngdale nj 07727 tel: 732.919.3119 fax: 732.751.5778 web: www .dialight.com 12 of 12 rev eco no. drn ckd app qa cm date a ---- sa ar kh rl jb 11-17-11 revision history www.datasheet.co.kr datasheet pdf - http://www..net/

▲Up To Search▲

Price & Availability of D464-R13-001

	To Download D464-R13-001 Datasheet File
If you can't view the Datasheet, Please click here to try to view without PDF Reader .